Sewer Pipe Lining (CIPP) in Cleveland

The pipe under a Cleveland house

Cleveland's housing stock is old by American standards. The East Side and West Side neighborhoods that fill the city between the lake and the inner-ring suburbs were largely built between 1890 and 1930, and even the post-war streets in West Park, Old Brooklyn and Lee-Harvard were finished by the early 1960s. That age shows in the sewer laterals. The typical Cleveland lateral is vitrified clay tile in two- or three-foot lengths, joined with mortar or, later, rubber gaskets, running from a cast iron stub at the foundation wall out to the street main. Under the basement floor and through the wall the pipe is usually cast iron, and in the oldest houses the basement floor drain and the storm connection share the same line.

Clay tile itself lasts a long time. The joints do not. Every joint is a place for a root to enter and for the pipe to shift, and a Cleveland lateral may have forty of them between the house and the main. Cast iron under the slab fails differently: the bottom of the pipe channels out from decades of acidic sewage sitting in it, so the pipe looks fine from the top on a camera pass and is paper-thin underneath.

Soil, water and trees

The city sits on the Lake Erie lake plain, and most of it is heavy glacial clay with a high water table, especially in the flats along the river and the lake. Clay holds water against the pipe, moves with freeze-thaw cycles, and settles under driveways that were poured decades after the sewer went in. The result is offset joints and bellies, low spots that hold water and collect grease and paper. Cleveland's tree lawns are planted with maples, sycamores and oaks that are now sixty to a hundred years old, and their roots find every joint in the lateral beneath them. Root intrusion is the single most common finding on a sewer camera inspection in Cleveland.

Combined sewers and who owns what

Much of the older city is served by combined sewers that carry sanitary flow and stormwater in one pipe; the Northeast Ohio Regional Sewer District operates the regional interceptors and treatment plants, while the city and each suburb maintain the local sewers in the street. The lateral from the house to the main is, in nearly every case, the property owner's responsibility for its whole length, including the part under the sidewalk and tree lawn. That is why a failed lateral is a homeowner problem and not something the city fixes, and it is why repair work in the public right of way needs a permit and an inspection in addition to the plumbing permit for the work on the lot.

Which trenchless method fits a Cleveland lateral

A camera inspection decides this, not a sales visit. The footage usually points one of three ways.

• Cured-in-place pipe lining is the answer for the most common Cleveland finding: clay tile with root-intruded, slightly offset joints that still holds its shape and slope. A resin-saturated liner cured inside the old pipe seals every joint at once and leaves a jointless pipe rated for decades. It also handles channeled cast iron under the basement floor without breaking up the slab.
• Pipe bursting is for a lateral that has collapsed, has a long belly, or was undersized to begin with. A new fused polyethylene pipe is pulled through the path of the old one from a pit at the house and a pit near the main, so the driveway and the tree lawn between them stay put.
• Sectional point repair fixes one crushed joint or one root ball on an otherwise sound line, which is common where a lateral crosses a gas trench or runs under a driveway apron.

Open trenching still makes sense on a short, shallow run under open lawn, and an honest contractor will say so. Under a driveway, a mature tree or a city sidewalk, trenchless is almost always the cheaper total job once restoration is counted.

What a Cleveland job looks like

Expect a hydro jetting pass first, because a root-choked lateral cannot be inspected or lined until the wall of the pipe is visible. Then the camera pass, with the locator marking depth and position on the lawn. Lining is done from the basement cleanout or a small access at the foundation and is usually finished in a day, with the water off for a few hours during the cure. A second camera pass records the finished pipe, and where the work touched the right of way the city inspects before anything is backfilled. Keep the video; it is the best record of the line you will ever have, and it matters at resale.

Sewer Pipe Lining (CIPP) in Cleveland

How cured-in-place lining works

A felt or fiberglass tube is saturated with resin, pulled or inverted into the cleaned host pipe, pressed against the wall with air or water, and cured with hot water, steam or UV light. When it hardens you have a new, jointless pipe inside the old one. The liner takes up a small amount of diameter, but its smooth wall flows better than corroded cast iron or offset clay. Lateral liners are typically rated for a 50-year service life.

What has to happen first

A camera inspection to map the line and every branch connection, hydro jetting to strip roots and scale so the resin bonds to clean pipe, and measurement so the liner is cut to length. After the cure, branch connections are reopened from inside with a robotic cutter and the line is filmed again.

When lining is the right fix

• Root intrusion at joints, longitudinal cracks, small offsets, pinholes or channeling in cast iron — on a pipe that is still round and holding grade.
• Lines under slabs, driveways, mature landscaping or streets, where the cost of a trench is mostly the cost of restoring what is above it.
• Coastal and high-water-table lots where an open trench means dewatering and shoring.

When it is not

Collapsed pipe, bellies that hold standing water, and lines that were undersized to begin with. A liner follows the host pipe's shape, so a bad shape stays bad. Those lines get pipe bursting or a spot replacement. Under-slab cast iron with several tight bends usually gets a spray-applied liner rather than felt.

Questions worth asking

What resin system and cure method will be used, what the liner's rated life is, whether the branch connections were counted, who pulls the permit, and whether you will receive the before-and-after video. A contractor who does this every week answers all five without hesitation.

ZIP codes served in Cleveland

Sewer Pipe Lining (CIPP) is available throughout Cleveland, including ZIP codes 44101, 44103, 44104, 44105, 44106, 44108, 44109, 44110, 44111, 44112, 44113, 44114, 44115, 44118, 44119, 44120, 44121, 44124, 44125, 44126, 44127, 44128, 44129, 44130, 44134, 44135, 44143, 44144, 44181, 44188, 44190, 44191, 44192, 44193, 44194, 44195, 44197, 44198, 44199.

More trenchless services in Cleveland

Questions we hear in Cleveland